新型旋转抛物面换能器阵列的设计

doi:10.12305/j.issn.1001-506X.2021.03.05

摘要/Abstract

摘要：

针对常见的一维线阵列和二维平面阵存在能量转化率低、成本高和加工精度要求高等问题, 在构建任意三维阵列的指向性函数的基础上, 设计了一种旋转抛物面型换能器阵列。将平面型换能器阵列旋转成抛物面型，利用指向性函数确定旋转抛物面型换能器阵列相应参数的最优值。仿真对比实验及其分析表明, 该新型阵列可以在减少换能器阵元使用数量、增大阵元间距的同时, 改善阵列的指向性, 并能提高声能量转化效率, 使更多的声能集中在主瓣方向。

关键词: 超声波, 换能器, 阵列, 指向性, 旋转抛物面

Abstract:

Aiming at the problems of low energy conversion rate, high cost and high machining accuracy in common one-dimensional linear array and two-dimensional planar array, a rotating paraboloid transducer array is designed based on the construction of directivity function of arbitrary three-dimensional array. The planar transducer array is rotated into a paraboloid type, and the optimal parameters of the rotating paraboloid transducer array are determined by the directivity function. The simulation results show that the new array can not only reduce the number of transducer elements, but also increase the array spacing, improve the directivity of the array, and improve the efficiency of acoustic energy conversion, so that more acoustic energy is concentrated in the direction of the main lobe.

Key words: ultrasound, transducer, array, directivity, rotating paraboloid

中图分类号:

TN912

谭笑枫, 李夕海, 曾小牛, 康志谦, 李广帅. 新型旋转抛物面换能器阵列的设计[J]. 系统工程与电子技术, 2021, 43(3): 631-636.

Xiaofeng TAN, Xihai LI, Xiaoniu ZENG, Zhiqian KANG, Guangshuai LI. Design of novel rotary paraboloid transducer array[J]. Systems Engineering and Electronics, 2021, 43(3): 631-636.

图/表 10

图1

图2

图3

图4

图5

图6

图7

图8

图9

图10

参考文献 29

1	陈敏.声频定向系统理论与关键技术研究[D].成都: 电子科技大学, 2008.
	CHEN M. Research on the theory and key technologies of audio directional system[D]. Chengdu: University of Electronic Science and Technology of China, 2008.
2	郑贤中.高指向性音频声波理论与控制研究[D].武汉: 华中科技大学, 2006.
	ZHENG X Z. Theory and control of high directivity audio aound wave[D]. Wuhan: Huazhong University of Science & Techno-logy, 2006.
3	陈晶晶, 邹彬彬, 王润田. 关于参量阵声源阵长的讨论[J]. 声学技术, 2016, 35 (5): 426- 429.
	CHEN J J , ZOU B B , WANG R T . Discussion on parametric acoustic array length[J]. Technical Acoustics, 2016, 35 (5): 426- 429.
4	CHENG Y , XU J Y , LIU X J . Tunable sound directional beaming assisted by acoustic surface wave[J]. Applied Physicsletters, 2010, 96 (7): 071910.
5	GUARATO F , JAKOBSEN L , VANDERELST D , et al. A method for estimating the orientation of a directional sound source from source directivity and multi-microphone recordings: principles and application[J]. The Journal of the Acoustical Society of America, 2011, 129 (2): 1046- 1058. doi: 10.1121/1.3519408
6	BENJAMIN K C , BUREN A L V , SZELAG J A , et al. A constant beamwidth transducer for ultrasonic applications[J]. The Journal of the Acoustical Society of America, 2006, 120 (5): 3067- 3067.
7	WYGANT I O, KUPNIK M, KHURI-YAKUB B T, et al. The design and characterization of capacitive micromachined ultrasonic transducers (CMUTs) for generating high-intensity ultrasound for transmission of directional audio[C]//Proc.of the Ultrasonics Symposium, 2008.
8	LEIF B . Forty years of nonlinear ultrasound[J]. Ultrasonics, 2002, 40 (1-8): 11- 17. doi: 10.1016/S0041-624X(02)00084-7
9	YAMASHITA K , KATATA H , OKUYAMA M , et al. Arrayed ultrasonic microsensors with high directivity for in-air use using PZT thin film on silicon diaphragms[J]. Sensors and Actuators A: Physical, 2002, 97-98, 302- 307. doi: 10.1016/S0924-4247(02)00037-7
10	LAMBERTI N , ESPINOSA F R M D , IULA A , et al. Two-dimensional modelling of multifrequency piezocomposites[J]. Ultrasonics, 2000, 37 (8): 577- 583. doi: 10.1016/S0041-624X(99)00028-1
11	OPPENHEIM I J , JAIN A , GREVE D W . Electrical characterization of coupled and uncoupled MEMS ultrasonic transdu-cers[J]. IEEE Trans.on Ultrasonics Ferroelectrics & Frequency Control, 2003, 50 (3): 297- 304.
12	周晗昀, 黄善和. 宽带参量阵在浅地层剖面测量中的应用[J]. 浙江大学学报(工学版), 2020, 54 (5): 972- 977.
	ZHOU H Y , HUANG S H . Application of broadband parametric array in sub-bottom profile measurement[J]. Journal of Zhejiang University (Engineering), 2020, 54 (5): 972- 977.
13	ECCARDT P C , NIEDERER K . Micromachined ultrasound transducers with improved coupling factors from a CMOS compatible process[J]. Ultrasonics, 2000, 38 (1-8): 774- 780. doi: 10.1016/S0041-624X(99)00085-2
14	ZHANG J , HLADKY-HENNION A C , HUGHES W J , et al. A miniature class V flextensional cymbal transducer with directional beam patterns: the double-driver[J]. Ultrasonics, 2001, 39 (2): 91- 95. doi: 10.1016/S0041-624X(00)00055-X
15	李颂文. 参量阵及其在水声工程中的应用进展[J]. 声学技术, 2011, 30 (1): 9- 16.
	LI S W . Parametric array and its application in underwater acoustic engineering: an overview[J]. Technical Acoustics, 2011, 30 (1): 9- 16.
16	LEE W , ROH Y . Ultrasonic transducers for medical diagnostic imaging[J]. Biomedical Engineering Letters, 2017, 7 (2): 91- 97. doi: 10.1007/s13534-017-0021-8
17	MARTINEZ O , MOSTAFA A , LUIS G , et al. A small 2D ultrasonic array for NDT applications[J]. NDT and E International, 2003, 36 (1): 57- 63. doi: 10.1016/S0963-8695(02)00072-5
18	SHI C , GAN W S . Development of parametric loudspeaker[J]. IEEE Potentials, 2010, 29 (6): 20- 24. doi: 10.1109/MPOT.2010.938148
19	杜鹏, 汤惠, 曹光亮. 超声调制的声频定向传输效率分析[J]. 压电与声光, 2015, 37 (5): 907- 911.
	DU P , TANG H , CAO G L . The efficiency analysis of ultrasound-modulated audio directional transmission[J]. Piezoelectrics & Acoustooptics, 2015, 37 (5): 907- 911.
20	宋蕊, 张明, 冯怡斯. 压电MEMS超声换能器阵列声场研究[J]. 压电与声光, 2015, 37 (2): 219- 222.
	SONG R , ZHANG M , FENG Y S . Research on sound field of MEMS piezoelectric ultrasonic transducer array[J]. Piezoelectrics & Acoustooptics, 2015, 37 (2): 219- 222.
21	杨天文, 陈敏, 黄大贵, 等. 换能器阵列形式对指向性的影响[J]. 压电与声光, 2014, 36 (1): 93- 96.
	YANG T W , CHEN M , HUANG D G , et al. Effect of transducer's array pattern on array's directivity[J]. Piezoelectrics & Acoustooptics, 2014, 36 (1): 93- 96.
22	PARK C Y , SUNG J H , JEONG J S . Design and fabrication of linear-array ultrasonic transducer using KLM and FEM simulation for non-destructive testing[J]. Journal of the Korean Society for Nondestructive Testing, 2015, 35 (2): 120- 127. doi: 10.7779/JKSNT.2015.35.2.120
23	TSENG W . Acoustic beam forming using ultrasonic transdu-cers[J]. Advanced Engineering Forum, 2012, 4, 238- 242. doi: 10.4028/www.scientific.net/AEF.4.238
24	刘健康, 王莉, 鲁五一, 等. 影响超声换能器阵指向性的几个关键因素研究[J]. 压电与声光, 2013, 35 (4): 564- 567. doi: 10.3969/j.issn.1004-2474.2013.04.025
	LIU J K , WANG L , LU W Y , et al. Study on several key factors of fluencing the directivity of ultrasonic transduer array[J]. Piezoelectrics & Acoustooptics, 2013, 35 (4): 564- 567. doi: 10.3969/j.issn.1004-2474.2013.04.025
25	宋寿鹏, 张瑜, 吴华清. 全矩阵线形超声换能器阵列声场仿真与设计[J]. 电子测量技术, 2019, 42 (20): 162- 168.
	SONG S P , ZHANG Y , WU H Q . Simulation and design of acoustic field for full matrix linear transducer array[J]. Electronic Measurement Technology, 2019, 42 (20): 162- 168.
26	WANG Z H , ZHU W G , MIAO J M , et al. Micromachined thick film piezoelectric ultrasonic transducer array[J]. Sensors & Actuators A Physical, 2006, 130 (2): 485- 490.
27	HU H W , DU J , YE C B , et al. Ultrasonic phased array sparse-tfm imaging based on sparse array optimization and new edge-directed interpolation[J]. Sensors, 2018, 18 (6): 1806- 1830. doi: 10.3390/s18061806
28	栾桂冬, 张金铎, 王仁乾. 压电换能器和换能器阵[M]. 北京: 北京大学出版社, 2004.
	LUAN G D , ZHANG J D , WANG R Q . Piezoelectric transducer and transducer array[M]. Beijing: Peking University Press, 2004.
29	李道江, 陈航, 倪云鹿. 阵元间互辐射对基阵指向性的影响研究及试验[J]. 声学学报, 2012, (3): 319- 323.
	LI D J , CHEN H , NI Y L . Research and experiments of mutual radiation impedance effect on array directivity[J]. Acta Acustica, 2012, (3): 319- 323.

[1]	张逸群, 兰岚, 廖桂生, 许京伟. 基于二次补偿的FDA-MIMO雷达抗主瓣欺骗式干扰方法[J]. 系统工程与电子技术, 2022, 44(9): 2769-2775.
[2]	胡毅立, 赵永波, 陈胜, 牛奔. 双插值拟合的共形电磁矢量传感器阵列解相干[J]. 系统工程与电子技术, 2022, 44(8): 2393-2402.
[3]	刘甲磊, 马佳智, 施龙飞. 虚拟波束四阶累积量DOA估计方法[J]. 系统工程与电子技术, 2022, 44(7): 2134-2142.
[4]	曲志昱, 孙萌, 戴幻尧. 基于共形阵的角度和极化信息联合估计算法[J]. 系统工程与电子技术, 2022, 44(6): 1798-1804.
[5]	王宇卓, 朱圣棋, 李西敏, 兰岚. FDA MIMO双基雷达主瓣走动矫正距离模糊杂波抑制[J]. 系统工程与电子技术, 2022, 44(5): 1483-1494.
[6]	韦娟, 严世安, 宁方立. 基于互质阵虚拟阵列空间平滑的相干信号DOA估计方法[J]. 系统工程与电子技术, 2022, 44(4): 1069-1077.
[7]	范保华, 左乐, 唐勇, 胡泽华. 基于最大期望算法的多时变信号DOA估计方法[J]. 系统工程与电子技术, 2022, 44(2): 420-426.
[8]	唐军奎, 刘峥, 谢荣, 曾波. MIMO雷达稀疏阵列优化设计方法[J]. 系统工程与电子技术, 2022, 44(12): 3661-3666.
[9]	游致远, 胡国平, 周豪. 基于冗余阵元优化的双基地嵌套MIMO雷达目标DOD和DOA联合估计方法[J]. 系统工程与电子技术, 2022, 44(12): 3696-3702.
[10]	窦山岳, 汪飞, 于伟强, 周建江, 陈军. 基于频控阵的多普勒波束锐化高度表设计[J]. 系统工程与电子技术, 2021, 43(9): 2383-2391.
[11]	鲁祖坤, 陈飞强, 孙一凡, 刘哲, 黄龙. 导航信号功率增强对阵列接收机的影响分析[J]. 系统工程与电子技术, 2021, 43(9): 2581-2587.
[12]	赵地, 邓中亮, 谭伟杰, 胡爱华, 唐诗浩. 空域滤波增益可调节的定向性均匀圆形阵列波达角估计[J]. 系统工程与电子技术, 2021, 43(7): 1804-1812.
[13]	王凌, 潘华, 赵维. 互耦效应下低复杂度的二维DOA估计算法[J]. 系统工程与电子技术, 2021, 43(7): 1819-1823.
[14]	兰岚, 许京伟, 朱圣棋, 廖桂生, 张玉洪. 波形分集阵列雷达抗干扰进展[J]. 系统工程与电子技术, 2021, 43(6): 1437-1451.
[15]	何炜琨, 刘昂, 王晓亮, 张莹, 陈敏. 机载阵列雷达风轮机回波信号建模与分析[J]. 系统工程与电子技术, 2021, 43(3): 666-675.